Fine-grained concrete with the addition of highly dispersed brick scrap powder

Cover Page

Cite item

Full Text

Open Access Open Access
Restricted Access Access granted
Restricted Access Subscription or Fee Access

Abstract

The use of brick breakage in concretes and in binder compositions is a promising direction for the development of recycling ceramic bricks. The purpose of the present research was to evaluate the possibility of using mineral powders obtained from brick breakage as an effective dispersed component in the production of fine-grained concrete. In the work, mechanical grinding of ceramic raw material was carried out at different grinding times. It wasestablished that for brick-breakage powders, an increase in the grinding time does not lead to a proportional increase in the specific surface area of the powders.The maximum effective increase in the specific surface area of the obtained powders is fixed at a grinding duration of up to 5 minutes. Using differential thermal analysis, it is shown that crushed brick is not an active mineral additive, but can act as crystallization centers during the formation of hydrosilicates in the structure of composites. Samples of fine-grained concrete were produced, in which part of the cement was replaced with ceramic powders obtained at different grinding duration. It was determined that the replacement of cement in concrete mixtures with this highly dispersed additive in an amount of 20% (by weight), obtained at an optimal grinding time in a ball mill, does not lead to a change in the physico-chemical characteristics of the final concrete composite.

Full Text

Restricted Access

About the authors

T. A. Drozdyuk

Northern (Arctic) Federal University named after M.V. Lomonosov

Author for correspondence.
Email: t.drozdyuk@narfu.ru

Candidate of Sciences (Engineering) 

Russian Federation, 17, Severnaya Dvina Emb., Arkhangelsk, 163002

A. M. Ayzenshtadt

Northern (Arctic) Federal University named after M.V. Lomonosov

Email: a.isenshtadt@narfu.ru

Doctor of Sciences (Chemistry), Professor 

Russian Federation, 17, Severnaya Dvina Emb., Arkhangelsk, 163002

Z. A. Pershin

Northern (Arctic) Federal University named after M.V. Lomonosov

Email: pershenz@gmail.com

Master’s Student 

Russian Federation, 17, Severnaya Dvina Emb., Arkhangelsk, 163002

V. E. Danilov

Northern (Arctic) Federal University named after M.V. Lomonosov

Email: v.danilov@narfu.ru

Candidate of Sciences (Engineering), Docent 

Russian Federation, 17, Severnaya Dvina Emb., Arkhangelsk, 163002

References

  1. Vladimirov S.N. Problems of recycling waste from the construction industry. Sistemnyye tekhnologii. 2016. No. 2 (19), pp. 101–105. (In Russian). EDN: WCNXNV
  2. Hammadhu Haither Ali, Anjali G. Sustainable urban development: Evaluating the potential of mineral-based construction and demolition waste recycling in emerging economies. Sustainable Futures. 2024. Vol. 7. 100179. https://doi.org/10.1016/j.sftr.2024.100179
  3. Goncharova M.A., Borkov P.V., Al-Surrayvi H.G.H. Recycling of large-capacity concrete and reinforced concrete waste in the context of realization of full life cycle contracts. Stroitel’nye Materialy [Construction Materials]. 2019. No. 12, pp. 51–57. (In Russian). https:// doi.org/10.31659/0585-430X-2019-777-12-52-57 EDN: KNFINX
  4. Sahoo P., Dwivedi A., Tuppad S.M., Gupta S. Sequestration and utilization of carbon dioxide to improve engineering properties of cement-based construction materials with recycled brick powder: a pathway for cleaner construction. Construction and Building Materials. 2023. Vol. 395. 132268. https://doi.org/10.1016/j.conbuildmat.2023.132268
  5. Yatsenko N.D., Yatsenko A.I. Use of industrial waste to improve the performance properties of ceramic bricks. Stroitel’nye Materialy [Construction Materials]. 2024. No. 4, pp. 37–42. (In Russian). https:// doi.org/10.31659/0585-430X-2024-823-4-37-42 EDN: BEDDFU
  6. Murtazaev S.-A.Yu., Khadisov V.Kh., Khadzhiev M.R. Using ceramic brick scrap to produce lightweight ceramic concrete. Ekologia i promyshlennost Rossii. 2014. No. 10, pp. 22–25. (In Russian). EDN: SQVWOD
  7. Beppaev Z.U., Astvatsaturova L.Kh., Kolodyazhny S.A., Vernigora S.A. Prospects for the use of recycled crushed stone from broken ceramic bricks as fillers for the production of concrete for general construction purposes. Vestnik of the Scientific Research Center “Construction”. 2020. Vol. 24. No. 1, pp. 13–22. (In Russian). https://doi.org/10.37538/2224-9494-2020-1(24)-13-22 EDN: DIPMOP
  8. Makhortov D.S., Zagorodnyuk L.Kh., Sumskoy D.A., Al’ Mamuri S.K.Sh. Obtaining binder compositions of optimal compositions based on Portland cement and broken ceramic brick waste. Vestnik of the BSTU named after V.G. Shukhov. 2022. No. 7, pp. 19–30. (In Russian). https://doi.org/10.34031/2071-7318-2022-7-7-19-30 EDN: QZAHQL
  9. Ukrainsky I.S., Mayorova L.P., Salikov D.A. Shevchuk A.S., Chainikov G.A. Reuse of scrap concrete and bricks as aggregates in concrete. Vestnik of the Peoples’ Friendship University of Russia. Series: Ecology and life safety. 2023. Vol. 31. No. 2, pp. 291–301. (In Russian). https://doi.org/10.22363/2313-2310-2023-31-2-291-301 EDN: NENFHQ
  10. Murtazaev S.-A.Yu., Uspanova A.S., Khadzhiev M.R., Khadisov V.Kh. Analysis of the influence of technogenic waste in the form of screenings from crushing ceramic waste on the basic properties of cement composites. Stroitel’nyye materialy i izdeliya. 2021. Vol. 4. No. 1, pp. 27–34. (In Russian). EDN: LJVZGS
  11. Galaeva N.L. The problem of recycling construction waste. Perspektivy nauki. 2019. No. 3 (114), pp. 50–53. (In Russian). EDN: FLOWHB
  12. Fomenko A.I., Gryzlov V.S., Kaptushina A.G. Waste ceramic bricks as an effective component of building composites. Sovremennie naukoyemkie tekhnologii. 2016. No. 2–2, pp. 260–264. (In Russian). EDN: VOIDLR
  13. Uspanova A.S., Ismailova Z.Kh., Khadisov V.Kh., Khadzhiev M.R. Construction mortars based on aggregates made from technogenic sands. Vestnik of the GSOTU. Technical science. 2020. Vol. 16. No. 3 (21), pp. 75–85. (In Russian). https://doi.org/10.34708/GSTOU.2020.70.83.010 EDN: DAQMLC
  14. Murtazaev S.-A.Yu., Khadisov V.Kh., Saidumov M.S., Khadzhiev M.R. Ceramic foam concrete based on broken bricks and manufacturing defects of bricks. Proceedings of the CI RAS. 2014. No. 7, pp. 53–60. (In Russian). EDN: TIVDNZ
  15. Kondrashchenko V.I., Ayzenstadt A.M., Danilov V.E., Tran Thi Mong Thu. Factor of mechanical activation of aggregate in increasing the performance properties of rotary concrete. Ekonomika stroitel’stva. 2024. No. 2, pp. 150–157. (In Russian). EDN: JLIYAK
  16. Kislyakov K.A., Yakovlev G.I., Pervushin G.N. Properties of a cement composition using broken ceramic bricks and microsilica. Stroitel’nye Materialy [Construction Materials]. 2017. No. 1–2, pp. 14–18. (In Russian). EDN: XXIHPX
  17. Beppaev Z.U., Astvatsaturova L.Kh., Kolodyazhny S.A., Vernigora S.A., Lopatinsky V.V. Determination of the physical and technical characteristics of recycled crushed stone from broken ceramic bricks with identification of prospects for its use as aggregates for concrete. Beton i zhelezobeton. 2022. No. 1 (609), pp. 36–42. (In Russian). https:// doi.org/10.31659/0005-9889-2022-609-1-36-42 EDN: SMFPAI

Supplementary files

Supplementary Files
Action
1. JATS XML
Download
2. Fig. 1. Functional dependence of the specific surface area of cullet powders on grinding duration

Download (30KB)
Indexing metadata
3. Fig. 2. Thermograms of broken brick samples

Download (48KB)
Indexing metadata
4. Fig. 3. Microstructure of fine-grained concrete samples: а – control sample; b – with the addition of crushed brick powder

Download (454KB)
Indexing metadata

Copyright (c) 2024 ООО РИФ "СТРОЙМАТЕРИАЛЫ"